论文部分内容阅读
我厂造气车间水煤气工段发生炉装置在1958年大跃进的基础上,1959年上半年又不断地創造了高产紀录,以无烟煤为原料,单炉造气量最大达到7800米~3/小时,单爐平均造气量亦由设计能力3200米~3/时提高至5750米~3/时。在厂党委的領导下,1959年下半年又繼續鼓足干劲,坚决克服了右倾松劲情緒,全厂掀起了一个以增产节約为中心的轰轰烈烈的群众运动高潮,使生产水平又大大提高了一步,两台炉造气时,单爐平均造气量达到了6364米~3/时,气化强度为1035米~3/米~2·时,平均气化率提高到1483米~3/吨无烟煤,水煤气有效气体組成(CO+H_2)亦由86.52％提高到87.18％。現将点滴經驗总结于后,以供参考。提高风压加大吹风强度无烟煤的反应活性較差,活性表面小,挥发份含量較高,因此需要通过提高爐溫的办法加以补
On the basis of the Great Leap Forward in 1958, the gas furnace section of the gas-making workshop in our factory continued to create high-yield records in the first half of 1959. With anthracite as the raw material, the maximum furnace-gas production reached 7800 m 3 / h, The average gas production capacity of a single furnace is also raised from the design capacity of 3200m ~ 3 / hour to 5750m ~ 3 / hour. Under the leadership of the Party Committee of the Factory, the second half of 1959 continued to work hard and resolutely overcame the sentiment toward the right. The entire factory set off a vigorous campaign of mass movements centered on boosting production and saving and greatly raised the level of production In one step, when the average gasification rate reached 6364 m 3 / h and the gasification intensity was 1035 m 3 / m 2 · s, the average gasification rate increased to 1483 m 3 / t Anthracite, water gas effective gas composition (CO + H_2) also increased from 86.52% to 87.18%. Now bit by bit experience summarized later, for reference. Improve the wind pressure to increase hair strength anthracite poor reactivity, small active surface, high volatile content, so you need to increase by way of increasing the furnace temperature