【摘 要】
：
The computational fluid dynamics(CFD)approach can be used to obtain both internal and external characteristics of centrifugal pumps,and the variations of the hydrodynamic force,the pressure and the torque on the blades acquired by the CFD are highly assoc
【机 构】
：
College of Water Conservancy and Hydropower Engineering,Hohai University,Nanjing 210024,China
论文部分内容阅读
The computational fluid dynamics(CFD)approach can be used to obtain both internal and external characteristics of centrifugal pumps,and the variations of the hydrodynamic force,the pressure and the torque on the blades acquired by the CFD are highly associated with the safety of the pumping system.Based on the CFD simulations,this paper investigates the stopping characteristics of multiple pumps with some pumps being stopped.The 3-D geometric model is built,including all 6 pumps,the valves,the pipes,the tanks and other components,and using the Realizable k-ε turbulence model.The CFD results for the operating points agree well with the results from the theoretical analysis.With some pumps being stopped,the key parameters of the operating pumps would not be stable,with a larger fluctuation;the direction of the hydrodynamic force might be opposite with more than 3 stopped pumps.For the stopped pumps,the maximum reverse values of the discharge and the rotational speed would be larger when fewer pumps are stopped,and could be more than 120％of the rated values,which is dangerous for the pumping system.The CFD results could help understanding the stopping process of multiple pump systems with some pumps being stopped.
其他文献
研究了采用氯化铵-盐酸体系从烧结电除尘灰中浸出金属铅,考察了氯化铵浓度、盐酸浓度、固液质量体积比、浸出温度、浸出时间对铅浸出率的影响,并探讨了浸出机制。结果表明:在NH4Cl浓度2 mol/L和HCl浓度1.5 mol/L、浸出温度70℃、浸出时间30 min、固液质量体积比为1 g/4 mL条件下,铅浸出率为98.6%;NH4Cl的加入可以提高溶液氢离子活度,实现低酸浓度下铅的有效浸出。
When studying the flow dynamics and the characteristics of fluid motion,vortex structure with their interactions is the key issue.In the present work,a vortex control method is investigated based on the vortex identification system of Liutex.The numerical
根据热力学数据,绘制了25℃条件下NdCl3-AlCl3-NH4HCO3体系在总碳浓度为1.0 mol/L条件下各组分的lg cB-pH曲线,以及在不同总碳浓度条件下Al与Nd的lg cB-pH曲线;分析了用碳酸氢铵沉淀稀土时各组分的行为。结果表明:pH在2.8~7.0范围内,可实现Nd2(CO3)3沉淀;pH在2.8~3.7范围内,铝不易与稀土共沉淀,
An iterative time-marching scheme is developed to investigate the hydrodynamic interactions between multiple ships.Such an unsteady interactive effect could be magnified in restricted waterways,e.g.,a channel or harbor area.To the author\'s knowledge,ne
Vortical structures of a submarine with appendages are fully turbulent and complex.Thus,flow control and vortex manipulation are of great importance for the hydrodynamic performance and acoustic characteristics.Take the generic submarine model DARPA Subof
The incompressible unsteady Reynolds-averaged Navier-Stokes(URANS)simulations are performed for a free-running container ship in maneuvering conditions:the starboard and portside turning circle simulations with 35° rudder deflection.The validation variabl
For complex aerodynamic and hydrodynamic problems,the analysis of vortex is very important.The Liutex method is an eigenvalue-based method which is local,accurate,and unique,which can give an accurate definition of vortex,so the control of vortex can be i
This paper proposes a 3-D non-hydrostatic free surface flow model with a newly proposed general boundary-fitted grid system to simulate the nonlinear interactions of the bi-chromatic deep-water gravity waves.First,the monochromatic bidirectional and bi-ch
研究了在工业电解槽中利用人工铜柱模拟结瘤及其生长行为,考察了电解时间和结瘤初始高度对结瘤形貌和生长速率的影响。结果表明:阴极电流随极间距减小而显著增大;电解时间小于12 h,结瘤形貌变化不大;电解时间延长至24 h,7.5 mm是结瘤形貌显著变化的临界高度:当结瘤初始高度大于7.5 mm后,其顶端出现明显的冠状膨大;当阴极板表面的结瘤高度小于2.5 mm且电解时间小于12 h时,其径向生长速率较快;除此以外,均以轴向生长为主导。
为实现工业电解槽电极电流在线测量并及时发现极间短路,利用计算机数值模拟研究了槽间导电排的磁场分布,确定合适的霍尔传感器测量位置、测量方法,推导出电极电流的计算模型。试验电解槽上的测试结果表明,所提出的方法测量偏差小于1.5%,满足工业测量要求。